Is there a fuse for fuel pump?
Most fuel pumps will run a 15 (Blue) 20 (Yellow) or 25 (Clear) amp fuse. Using a fuse that’s too small will cause the fuse to blow again.
Why does my 15 amp fuse keep blowing?
Having too many devices plugged into a circuit is the most common cause of fuses blowing. Another potential cause of fuses blowing is a short circuit. When a hot wire touches either the grounding pathway or a neutral wire, it results in the circuit shorting out.
What causes the fuse to blow on a fuel pump?
I would start at the fuel pump itself. If the fuse blows as soon as you turn on the key, undo the connector at the tank to the pump and put in a new fuse. Try it again, if the fuse pops then your short is before that point likely a chafed wire on the body. If the fuse stays good then the problem is in the pump harness or the fuel pump itself.
What are the symptoms of a faulty fuel pump relay?
1 Engine does not start. A common symptom of a faulty fuel pump relay is an engine that just refuses to start, even though the engine may still crank when the 2 Engine stalls. One of the most common symptoms of a failing fuel pump relay is an engine that suddenly stalls. 3 Loss of Power. 4 No noise from the fuel pump. …
What happens when a fuel pump goes bad?
The engine turns off if the combustion chamber’s fuel is inadequate or doesn’t have the proper pressure. The part that ensures none of this happens is the fuel pump, and it cannot work perfectly if the fuel pump relay develops any issues. A faulty fuel pump relay can also cause the engine not to start at all and be completely dead.
Where is the fuel pump fuse box located?
The engine’s or the dashboard fuse box is usually a long black box containing a fuel pump relay and various other fuses and relays. For different vehicles, the fuel pump relays can be located in different places.
I would start at the fuel pump itself. If the fuse blows as soon as you turn on the key, undo the connector at the tank to the pump and put in a new fuse. Try it again, if the fuse pops then your short is before that point likely a chafed wire on the body. If the fuse stays good then the problem is in the pump harness or the fuel pump itself.
When did I replace the fuel pump in my S10?
In April I replaced a fuel pump in my S10. When they replaced it , it blew a 20 amp fuse. They put in new fuse and it ran fine till this week. 5 months later. The fuel pump was bad and was replaced under warranty.
Can a fuel pump overload cause a problem?
If not, check the other loads on the fuel pump circuit as those other loads could be causing the problem (the overload). To check that refer to wiring diagram in Factory Service Manual.
What causes fuel pump to draw more current than intended?
There is also the possibility of a physical (mechanical) restriction in the fuel pump tubing, filter and/or pick up causing the motor to overload and draw more current than intended. That’s why you should measure the actual current draw of the pump in normal operation to rule that out.